PNK\BLK SHFT SOL 1 PNK\RED SHFT SOL 2 VIO\BLK LINE PRES + GND POWER BLK YELLOW 18AWG YEL\ORG GRY\BLK GRY\GRN GRY\RED VIO\RED VIO\LT.

Tamaño: px
Comenzar la demostración a partir de la página:

Download "PNK\BLK SHFT SOL 1 PNK\RED SHFT SOL 2 VIO\BLK LINE PRES + GND POWER BLK YELLOW 18AWG YEL\ORG GRY\BLK GRY\GRN GRY\RED VIO\RED VIO\LT."

Transcripción

1 2 H G F E D C B A TCU TCU-2800 Connector QTY DESCRIPTION PCS P\N NOTES 1 CONNECTOR CON-1202 M\F 35 TERMINALS CON CONNECTOR COVER CON CAVITY PLUG CON-1204 \\PWR2950\PCS_WORK\PCS PRODUCTS\TRANSMISSION CONTROLLERS\TCM-2800\HARNESSES\TCM GM 4L L70E ( )\TCM GM 4L L70E ( ).VSD FULL FILENAME BRN\LT.BLU GRY\BLK GRY\RED GRY\LT.GRN GRY\LT.BLU GRY\WHT GRY\ORN GRY\YEL BLK\WHT GRY\PNK VIO\BLK VIO\RED VIO\LT.GRN VIO\LT.BLU WHT\RED WHT\BLK ORN\WHT YEL (OUT) YEL (IN) RED RED\WHT BLK\WHT BLK\WHT ORN\BLK ORN\RED BLK RED WHT BRN\BLK BRN\RED BLK\WHT SEN GND CAN1 HI CAN1 LOW SW +12V SIG GND SIG GND SPEED 1 SPEED 2 COM TX SIG GND ORN\LT.GRN SPEED IN 3 YEL\BLK YEL\ORN PNK\RED CLASS 2 SER DATA DIG IN 1 DIG IN 2 DIG IN 3 DIG IN 4 DIG IN 5 DIG IN 6 DIG IN 7 DIG IN 8 PWM1 PWM2 PWM3 PWM4 SW +12V OUT COM RX COM GND DIG IN 9 DIG IN 10 ORN\LT.BLU SPEED IN 4 PNK\LT.GRN PNK\BLK SPEEDO OUT +12V BATT +5V REF BRN\LT.GRN DIG IN 11 BRN\LT.BLU DIG IN 12 BRN\WHT DIG IN 13 BRN\ORN DIG IN 14 BRN\YEL DIG IN 15 BRN\PNK DIG IN 16 VIO\WHT PWM 9 DIG OUT 4 BLK GND 2 YELLOW GREEN YEL\RED YEL\LT.GRN YEL\LT.BLU YEL\WHT CAN 2 HIGH CAN 2 LOW ANA IN 1 ANA IN 2 ANA IN 3 ANA IN 4 ANA IN 5 ANA IN 6 VIO\WHT PWM 5 VIO\ORN PWM 6 PWM 7 PWM 8 PNK\WHT DIG OUT 5 PNK\ORN DIG OUT 6 F1 & F2 QTY DESCRIPTION PCS P\N NOTES 2 CONNECTOR CON FUSE CAP: CON-2201 BLK 2 TPA CON-2202 BLU 4 TERMINAL CON-1020 (18-16 AWG) 1 FUSE - 1 CON A 1 FUSE - 2 CON A 4 CABLE SEAL CON-1001 GRN SEE PAGE 3 18 AWG 18 AWG S1 16 AWG 18 AWG 18 AWG SPLICE INFORMATION S-# FUNCTION COLOR S1 12 VOLTS SWITCHED YELLOW S2 GROUND BLK S3 SENSOR GROUND BLK\WHT S4 CAN HIGH WHT\RED S5 CAN LOW WHT\BLK S2 18 AWG 18 AWG 16 AWG Fuse Assembly +12 VOLTS 20 AWG RED YELLOW F2 3A A B S3 16 AWG A B F1 10A 18AWG YELLOW PNK\BLK YELLOW YEL\ORG BLK\WHT ORG\RED BLK\WHT BLK GRY\BLK GRY\GRN GRY\RED ORN\LT.GRN BLK\WHT 16 AWG SHFT SOL 1 PNK\RED SHFT SOL 2 VIO\BLK LINE PRES + GND POWER FLUID TEMP SENSOR GND RANGE A RANGE C RANGE B TOSS SIGNAL GND TISS SIGNAL GND A B A B C D E F G H J K L M N P R S T U V W A B C-1 C-2 60" C-3 60" 60" CHASSIS GND IGNITION SWITCHED +12 VOLTS TRANSMISSION CONNECTOR FRONT VIEW 60" UNTERMINATED CHASSIS GND QTY DESCRIPTION PCS P\N NOTES 1 RING TERM. CON-0350 C-1TRANSMISSION CONNECTOR QTY DESCRIPTION PCS P\N NOTES 1 CONNECTOR CON TERMINAL CON AWG. 1 TERMINAL CON AWG 5 CAVITY PLUG CON-1044 BLU 1 MULTI CABLE SEAL CON-3309 LT.GRN 1 CONDUIT CLIP CON-2008 BLK 1 TPA CON-2003 GRY C-2 OUTPUT SHAFT SPEED SENSOR FEMALE QTY DESCRIPTION PCS P\N NOTES 1 CONNECTOR CON TERMINALS CON AWG 2 CABLE SEAL CON-1093 GRN 1 TPA CON-1072 GRY C-3 INPUT SHAFT SPEED SENSOR QTY DESCRIPTION PCS P\N NOTES 1 CONNECTOR CON TERMINALS CON AWG 2 CABLE SEAL CON-1093 GRN 1 TPA CON-1072 GRY ORN\LT.BLU VIO\LT.GRN BLK\WHT RED WHT BLK TURB SPEED+ TCC ON\OFF TCC PWM- SERIAL RX. RS232 GND SERIAL TX. A 15" B C-4 YELLOW 18 AWG POWER 60" 1 BLK 18 AWG GND 2 C-5 CAN High TWISTED 3 PAIR CAN Low 4 S4 WHT\RED CAN High 1 60" TWISTED WHT\BLK PAIR CAN Low 2 C-6 S5 BLK Fuse Assembly +12 VOLTS RED VIO\RED BLK\WHT YEL\BLK RED\WHT BLK\WHT ORN\BLK ORN\WHT BRN\BLK YEL/RED VIO\LT.BLU VIO\WHT 16 AWG 20 AWG TWISTED PAIR TWISTED PAIR SENSOR GND 3/8 RING TERMINAL TPS +5 VOLT SEN. TACHOMETER GROUND TACHOMETER SPEEDOMETER BRAKE LIGHT ANALOG IN 2 Print Date PWM OUT 4 PWM OUT 5 60" C A B C } +12V BATT 60" 9/12/ " 60" C-7 TWISTED PAIR 60" A D 3 K E A B A B C B A A B C APPLICABLE STANDARDS ASME Y ASME Y14.5M-1994 TURB SPEED- IPC/WHMA-A-620A- CLASS 2 1 RELEASE 2 MARK IAW MIL-STD-130. L T S W R OUTPUT SHAFT SPEED SENSOR FRONT VIEW INPUT SHAFT SPEED SENSOR LAPTOP CAL CONNECTOR OPTION FRONT VIEW CAN CONNECTOR THROTTLE POSITION SENSOR REVISION LEVEL LEVEL DESCRIPTION DATE DRN APP NOTES: 1.) WIRE LENGTH TOLERANCE +/- 1\2 INCH 2.) WIRE GAUGE IS 20 AWG UNLESS OTHERWISE STATED 3.) TAPE ALL LOOM JOINTS UNLESS OTHERWISE STATED 4.) TWIST INDICATED WIRES AT LEAST TURNS PER FOOT 5.) PLACE TAGS NO MORE THAN 2" FROM CONNECTOR. PLACE TAGS FOR UNTERMINATED WIRES NO MORE THAN 2" FROM UNTERMINATED END. 6.) WIRE TYPE IS TXL UNLESS OTHERWISE STATED C-4 LAPTOP CAL CONNECTOR QTY DESCRIPTION PCS P\N NOTES 1 CONNECTOR CON TERMINALS CON TPA CON-3417 CREAM 3 CABLE SEALS CON-1027 WHT C-5 OPTION QTY DESCRIPTION PCS P\N NOTES 1 CONNECTOR CON TERMINALS CON-0051 C-6 CAN BUS CONNECTOR QTY DESCRIPTION PCS P\N NOTES 1 CONNECTOR CON TERMINALS CON-5200 (20-18gauge) 1 WEDGE LOCK CON-5100 ORN C-7 THROTTLE POSITION CONNECTOR QTY DESCRIPTION PCS P\N NOTES 1 CONNECTOR CON TERMINALS CON CABLE SEALS CON-1004 VIO COMPANY: C-7M THROTTLE THROTTLE POSITION POSITION SENSOR PIGTAI QTY DESCRIPTION PIGTAIL CONNECTOR PCS P\N NOTES 1 CONNECTOR CON TERMINALS CON AWG 2 CABLE SEALS CON-1004 VIO 1 PLUG CON-0999 GRN C B A CUSTOMER DRAWING NO. C-7M A B C SENSOR GND DRAWN BY: DATE: APPROVED BY: DATE: 1730 FAD SHEET 9/14/2016 TITLE: C C TPS PCS PART NUMBER BLK\WHT YEL\BLK POWERTRAIN CONTROL SOLUTIONS GM 4L60/65, 4L70E ( ) TCM-2800 HARNESS REV: NONE TCM PAGE 2 OF 12 H G F E D C B A

2 REVISION LEVEL LEVEL DESCRIPTION DATE DRN APP 1 RELEASE H H G F E D C B TCU TCU-2800 Connector QTY DESCRIPTION PCS P\N NOTES 1 CONNECTOR CON-1202 M\F 36 TERMINALS CON CONNECTOR COVER CON CAVITY PLUG CON BRN\LT.BLU CLASS 2 SER DATA GRY\BLK DIG IN 1 GRY\RED DIG IN 2 GRY\LT.GRN DIG IN 3 GRY\LT.BLU DIG IN 4 GRY\WHT DIG IN 5 GRY\ORN DIG IN 6 GRY\YEL DIG IN 7 BLK GND GRY\PNK DIG IN 8 VIO\BLK PWM1 VIO\RED PWM2 VIO\LT.GRN PWM3 VIO\LT.BLU PWM4 WHT\RED CAN1 HI WHT\BLK CAN1 LOW ORN\WHT SPEEDO OUT YEL (OUT) SW +12V OUT YEL (IN) SW +12V RED +12V BATT RED\WHT +5V REF BLK\WHT SIG GND BLK\WHT SIG GND ORN\BLK SPEED 1 ORN\RED SPEED 2 BLK COM TX RED COM RX WHT COM GND BRN\BLK DIG IN 9 BRN\RED DIG IN 10 BRN\LT.GRN DIG IN 11 BRN\LT.BLU DIG IN 12 BRN\WHT DIG IN 13 BRN\ORN DIG IN 14 BRN\YEL DIG IN 15 BRN\PNK DIG IN 16 BLK\WHT SIG GND ORN\LT.GRN SPEED IN 3 ORN\LT.BLU SPEED IN 4 PNK\LT.GRN PWM 9 VIO\WHT DIG OUT 4 BLK GND 2 YELLOW CAN 2 HIGH GREEN CAN 2 LOW YEL\BLK ANA IN 1 YEL\RED ANA IN 2 YEL\LT.GRN ANA IN 3 YEL\LT.BLU ANA IN 4 YEL\WHT ANA IN 5 YEL\ORN ANA IN 6 VIO\WHT PWM 5 VIO\ORN PWM 6 PNK\BLK PWM 7 PNK\RED PWM 8 PNK\WHT DIG OUT 5 PNK\ORN DIG OUT 6 SEE PAGE 2 FOR CONNECTIONS SEE PAGE 2 FOR CONNECTIONS BRN\RED BRN\LT.GRN BRN\LT.BLU BRN\WHT BRN\ORN BRN\YEL BRN\PNK MANUAL MODE UP SHIFT DOWN SHIFT CALIBRATION A\B ENABLE CANCEL O\D SW 4 W\D LOW DYNO MODE ENABLE 60" UNTERMINATED GROUP G F E D C B A Print Date 2/5/ F1 & F2 QTY DESCRIPTION PCS P\N NOTES 2 CONNECTOR CON FUSE CAP: CON-2201 BLK 2 TPA CON-2202 BLU 4 TERMINAL CON-1020 (18-16 AWG) 1 FUSE - 1 CON A 1 FUSE - 2 CON A 4 CABLE SEAL CON-1001 GRN SPLICE INFORMATION S-# FUNCTION COLOR S1 12 VOLTS SWITCHED YELLOW S2 GROUND BLK S3 SENSOR GROUND BLK\WHT S4 CAN HIGH WHT\RED S5 CAN LOW WHT\BLK Print Date 9/12/ APPLICABLE STANDARDS ASME Y ASME Y14.5M-1994 IPC/WHMA-A-620A- CLASS 2 MARK IAW MIL-STD-130. DRAWN BY: FAD NOTES: 1.) WIRE LENGTH TOLERANCE +/- 1\2 INCH 2.) WIRE GAUGE IS 20 AWG UNLESS OTHERWISE STATED 3.) TAPE ALL LOOM JOINTS UNLESS OTHERWISE STATED 4.) TWIST INDICATED WIRES AT LEAST TURNS PER FOOT 5.) PLACE TAGS NO MORE THAN 2" FROM CONNECTOR. PLACE TAGS FOR UNTERMINATED WIRES NO MORE THAN 2" FROM UNTERMINATED END. 6.) WIRE TYPE IS TXL UNLESS OTHERWISE STATED DATE: 9/14/2016 COMPANY: TITLE: C C APPROVED BY: POWERTRAIN CONTROL SOLUTIONS GM 4L60/65, 4L70E ( ) TCM-2800 HARNESS CUSTOMER DRAWING NO. PCS PART NUMBER SHEET REV: NONE TCM DATE: PAGE 3 OF 12 A

3 H G F LABEL DEFINITION TABLE NUM NAME STOCK # NOTES L1 TCM P329 L2 CAN BUS P35 L3 THROTTLE POSITION SENSOR P2 L4 SWITCHED +12V DC P31 L5 CHASSIS GROUND P32 L6 LAPTOP CALIEBRATION CONNECTOR P65 L7 OUTPUT SHAFT SPEED SENSOR P8 L8 INPUT SHAFT SPEED SENSOR P7 L9 TRANSMISSION CONNECTOR P107 L10 TACHOMETER GROUND P33 L11 TACHOMETER P34 L12 SPEEDOMETER P39 L13 BRAKE LIGHT P38 L14 ANALOG IN P95 L15 MANUAL MODE P347 L16 UP SHIFT P348 L17 DOWN SHIFT P349 L18 PWM OUT P99 L19 PWM OUT P100 L20 OPTION CONNECTOR P5 L21 +12V BATTERY P30 L22 CALIBRATION A/B ENABLE P80 L23 CANCEL O\D SW P350 L24 4 W\D\LOW P81 L25 DYNO MODE ENABLE P54 54" TWISTED PAIR L3 60" C7 THROTTLE POSITION SENSOR PIN CIRCUIT FUNCTION COLOR CONNECTS TO A SEN.GND BLK\WHT S3 B TPS YEL\BLK TCU-45 C +5V SENSOR RED\WHT TCU-21 47" L2 L20 5" 5" 60" C5 60" C6 OPTION PIN CIRCUIT FUNCTION COLOR TCU POS. 1 POWER YEL S1 2 GND. BLK S2 3 CAN HIGH WHT\RED TCU-15, S4 4 CAN LOW WHT\BLK TCU-16, S5 CAN PIN CIRCUIT FUNCTION COLOR TCU POS. 1 CAN HIGH WHT\RED S4 2 CAN LOW WHT\BLK S5 30" 30" L7 L8 } } TWISTED PAIR TWISTED PAIR 60" 60" 2pin Blk 2pin Blk C2 C3 REVISION LEVEL LEVEL DESCRIPTION DATE DRN APP 1 RELEASE 1A ADDED HARNESS LABEL 2/5/16 FD OUTPUT SHAFT SPEED SENSOR PIN CIRCUIT FUNCTION COLOR TCU POS. A TOSS+ ORG\RED TCU-25 B TOSS- BLK\WHT TCU-22 INPUT SHAFT SPEED SENSOR PIN CIRCUIT FUNCTION COLOR TCU POS. A TISS+ ORG\LT.GRN TCU-38 B TISS- BLK\WHT TCU-37 } } TWISTED PAIR TWISTED PAIR H G F TCU-2800 CONNECTOR 0 6" 8" 30" L9 60" 20pin GM Transmission C1 E D C 12" L1 THROTTLE POSITION CONNECTOR MATE C-7M 18 AWG. RED 16 AWG. YEL 16 AWG. BLK F2 3A F1 10A 10 WIRES 48" 48" 56" L10 L19 L22 L25 L21 18 AWG. RED L4 16 AWG. YEL L5 16 AWG. BLK 60" 3/8 Ring Term UNTERMINATED CIRCUIT FUNCTION COLOR CONNECTS TO TACHOMETER GROUND BLK\WHT TCU-23 TACHOMETER ORN\BLK TCU-24 SPEEDOMETER ORN\WHT TCU-17 BRAKE LIGHT BRN\BLK TCU-29 ANALOG IN 2 YEL\RED TCU-46 PWM OUT 4 VIO\LT.BLU TCM-14 PWM OUT 5 VIO\WHT TCM-51 TRUE MANUAL MODE BLK\RED TCU-30 UP SHIFT BLK\LT.GRN TCU-31 DOWN SHIFT BLK\LT.BLU TCU-32 CAL "B" BLK\WHT TCU-33 CANCEL O\D BLK\ORN TCU-34 4 W\D LOW BLK\YEL TCU-35 DYNO MODE BLK\PNK TCU-36 F2 PIN CIRCUIT FUNCTION COLOR WIRES TO A +12 BATT FUSED RED TCU-20 B +12 BATT RED FUSED BATT SOURCE F1 PIN CIRCUIT FUNCTION COLOR WIRES TO A +12 BATT FUSED YEL TCU-19, S1 B +12 BATT YEL FUSED SW +12V SOURCE } TRANSMISSION CONNECTOR TWISTED PAIR PIN CIRCUIT FUNCTION COLOR CONNECTS TO A SHIFT SOL-A (1-2) PNK\BLK TCU-53 B SHIFT SOL B-(2-3) PNK\RED TCU-54 C LINE PRESSURE + VIO\BLK TCU-11 D LINE PRESSURE - BLK TCU-42, S2 E POWER YEL (18 AWG) TCU-19, S1 F NC NC NC G NC NC NC H NC NC NC J NC NC NC K TURB SPEED+ ORN\LT.GRN TCU-39 L ATF TEMP + YEL\ORG TCU-50 M ATF TEMP - BLK\WHT TCU-9, S3 N RANGE A GRY\BLK TCU-2 P RANGE C GRY\GRN TCU-4 R RANGE B GRY\RED TCU-3 S NC NC NC T TCC ON\OFF VIO\RED TCU-12 U TCC PWM- VIO\LT.GRN TCU-13 V TURB SPEED- BLK\WHT TCU-9, S3 W NC NC NC E D C B A THROTTLE POSITION SENSOR PIGTAIL PIN CIRCUIT FUNCTION COLOR GOES TO SENSOR GND BLK\WHT UNTERM A B TPS YEL\BLK UNTERM C NC NC NC WIRE COLOR ABBREVIATIONS TXT COLOR NOTES BLK BLACK BRN BROWN RED RED ORN ORANGE YEL YELLOW LT.GRN LIGHT GREEN GRN GREEN LT.BLU LIGHT BLUE BLU BLUE VIO VIOLET GRY GRAY WHT WHITE PNK PINK SPLICE INFORMATION S-# FUNCTION COLOR S1 12 VOLTS SWITCHED YELLOW S2 GROUND BLK S3 SENSOR GROUND BLK\WHT S4 CAN HIGH WHT\RED S5 CAN LOW WHT\BLK 9" L6 15" C4 LAPTOP CALIBRATION CONNECTOR APPLICABLE STANDARDS ASME Y ) WIRE GAUGE IS 20 AWG UNLESS OTHERWISE STATED ASME Y14.5M ) TAPE ALL LOOM JOINTS TITLE: UNLESS OTHERWISE LAPTOP CAL CONNECTOR IPC/WHMA-A-620A- STATED PIN CIRCUIT FUNCTION COLOR TCU POS. CLASS 2 4.) TWIST INDICATED WIRES AT LEAST TURNS PER A SERIAL RX. RED TCU-27 MARK IAW MIL-STD-130. FOOT B SIGNAL GND. WHT TCU-28 5.) PLACE TAGS NO MORE THAN 2" FROM CONNECTOR. PLACE Print Date C SERIAL TX. BLK TCU-26 TAGS FOR UNTERMINATED WIRES NO MORE THAN 2" C CUSTOMER DRAWING NO. PCS PART NUMBER FROM UNTERMINATED END. 9/12/ ) WIRE TYPE IS TXL UNLESS C OTHERWISE STATED 1730 DRAWN BY: DATE: APPROVED BY: DATE: FAD SHEET 9/14/2016 NOTES: 1.) WIRE LENGTH TOLERANCE +/- 1\2 INCH COMPANY: POWERTRAIN CONTROL SOLUTIONS GM 4L60/65, 4L70E ( ) TCM-2800 HARNESS REV: NONE TCM PAGE 4 OF 12 B A